2004 Ford Expedition recalls and problems

FORD SPECIAL SERVICE VEHICLE (SSV) EXPEDITIONS USE A STEEL FULL FACE WHEEL DESIGN SIMILAR TO THAT INVESTIGATED IN PE03009, RQ04007, EA04034 (CROWN VICTORIA POLICE INTERCEPTOR) AND PE03026 (GM PICKUPS AND SUVS).A TOTAL OF 8,251 SSVS (2.2% OF TOTAL PRODUCTION) WERE PRODUCED WITHIN MODEL YEARS 2004-2006 AND SOLD PRIMARILY FOR USE BY STATE, FEDERAL, AND MUNICIPAL LAW ENFORCEMENT (LE) AGENCIES.FORD STIPULATES THAT THE SUBJECT VEHICLES ARE NOT SUITABLE FOR HIGH SPEED OR PURSUIT OPERATIONS AND ALSO IDENTIFIED A 2004 NATIONAL INSTITUTE FOR JUSTICE VEHICLE EVALUATION REPORT WHICH ALSO ACKNOWLEDGES THIS LIMITATION. THE FULL FACE WHEEL IS FABRICATED FROM TWO PIECES: A STAMPED OUTER WHEEL DISC AND A FORMED RIM.THE TWO PIECES, WHICH TOGETHER COMPRISE THE OUTER BEAD SEAT, ARE JOINED TOGETHER WITH A CIRCUMFERENTIAL WELD.A CYCLIC BENDING MOMENT OCCURS IN THE OUTER BEAD SEAT AREA AS THE WHEEL ROTATES, RESULTING IN FATIGUE STRESSES IN THE WELD'S HEAT AFFECTED ZONE THAT CAN LEAD TO FRACTURING (CRACKING) OF THE RIM MATERIAL.BECAUSE THE FAILURE OCCURS UNDER THE OUTBOARD TIRE BEAD, AIR LEAKAGE MAY NOT READILY OCCUR WHEN THE RIM CRACKS, DEPENDENT ON HOW WELL THE BEAD SEALS ON THE RIM.IF MULTIPLE CRACKS GROW UNDETECTED AND SUDDENLY JOIN INTO A SINGLE LARGE CRACK, THE WHEEL'S STRUCTURE CAN BECOME COMPROMISED LEADING TO RAPID AIR LOSS.A RAPID AIR LOSS, ESPECIALLY AT HIGHER SPEED, MAY LEAD TO A CRASH. FORD RESPONDED TO ODI'S JANUARY 5, 2009 INFORMATION REQUEST (IR) ON FEBRUARY 24.FORD'S RESPONSE ACKNOW…

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VER…