2013 Nissan Altima recalls and problems

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been n…

On July 29, 2019, the Office of Defects Investigation (ODI) opened EA19002 to investigate instances of alleged rear lower control arm failures in 2013-2018 Nissan Altima and 2016-2018 Nissan Maxima vehicles. At the time the investigation was opened ODI had 91 consumer complaints alleging rear lower control arm failures in the subject vehicles.ODI was concerned about these complaints because many of them alleged an increased steering effort or loss of vehicle control.At the time these complaints were received, ODI was also aware of a proactive service campaign addressing 2013 Nissan Altima in salt-belt states for a similar concern. Since opening the investigation, ODI has confirmed, based on consumer complaints, warranty data, and testing conducted by Nissan and ODI, that owners of the subject vehicles are experiencing a corroded bushing at one of three mounting points of the control arm to the rear subframe.ODI has also confirmed that drivers become aware of the problem because of sound and abnormal vibrations. In addition, the failure mileage is typically over 113,000 miles at the time of failure.In conjunction with Nissan and VRTC, ODI participated in testing to assess the potential safety consequence of a bushing failure.It was found the Vehicle Dynamic Control system allows the driver to maintain vehicle control in the event of a bushing failure.With between 7 to 13 years of field exposure, ODI is aware of only one low speed crash allegation describing minor contact with …

PE18-013 was opened on December 1, 2018, with 4 complaints to ODI alleging incidents of the lower control arm fracturing at a connection point to the vehicle chassis due to corrosion. ODI has received an additional 87 complaints since the PE was opened. During PE18-013, Nissan indicated model years 2013-2018 shared a common rear lower control arm design. Nissan provided complaint and warranty data regarding 48 incidents of the subject failure. The majority of the complaints are from vehicles registered in salt belt states. There have been no crashes, injuries, or fatalities confirmed as of this date. Nissan advised that it has conducted testing to assess safety risk. Nissan states that due to low incident rate, high detectability, and low risk of adverse vehicle dynamics, it does not believe the subject lower control arm failure poses an unreasonable risk to motor vehicle safety.This preliminary evaluation has been upgraded to Engineering Analysis (EA) 19-002. During the EA, ODI will continue to collect and analyze complaint and field data in its efforts to fully assess the scope and frequency of the alleged defect. More importantly, ODI will also seek additional information and data regarding the potential safety consequences of rear lower control arm failure, both from evidence collected from field failures and through more rigorous and comprehensive vehicle testing to be conducted by either Nissan and/or NHTSA.The ODI reports (VOQs) cited above can be viewed at NHTSA.gov u…

In May 2016, Nissan North America issued a safety recall (16V-244) to address the problem of improper classification of adult front seat passengers in approximately 3.3 million vehicles, including those in the scope of this investigation when it was opened (almost one million vehicles) and additional vehicles, as shown below.Nissan models: certain model year 2013-2016 Altima, 2013-2016 LEAF, 2016-2017 Maxima, 2015-016 Murano and Murano Hybrid, 2013-2016 Pathfinder, 2014-2015 Pathfinder Hybrid, 2014-2017 Rogue, 2013-2016 Sentra, 2013-2016 NV200, and 2014-2016 Taxi.Infiniti models: certain model year 2013 JX35, 2014-2017 Q50, 2014-2016 Q50 Hybrid, and 2014-2016 QX60 and QX60 Hybrid.Chevrolet model: certain model year 2015-2016 City Express.Additional information on the above-referenced recalls is available online at NHTSA.gov.Also, the numbers shown in the above failure report summary are for the original vehicle population, as opposed to the entire recall population, and the ODI reports cited are as of May 31, 2016 when Nissan began to notify the affected owners of recall 16V-244.Based on the recall actions taken by Nissan, this Engineering Analysis is closed.Additional information on this closing resume and the investigation are in the EA15-004 public file available online at NHTSA.gov.The ODI reports cited above can be reviewed online at https://www.nhtsa.gov/recalls#vehicle under the following identification numbers: 10583283 10585264 10585349 10585379 10592434 10593399 105…

In April 2014, Nissan North America launched Safety Recall 14V-138 to address problems with the Occupant Classification System (OCS) algorithm in the following vehicles: model year (MY) 2013-2014 Nissan Altima, Pathfinder, Sentra and LEAF; MY 2013 Infiniti JX35; MY 2014 Infiniti QX60 and Q50; and MY 2013 Nissan NV 200/Taxi vehicles.According to Nissan, the OCS may misclassify adult front passenger occupants and turn off the passenger's frontal air bag for an adult occupant of sufficient weight.In March 2015, the Office of Defects Investigation (ODI) opened this Recall Query after the agency received approximately 124 complaints alleging problems with the OCS after the recall repairs and/or other OCS related repairs were made by Nissan/Infiniti dealers.The majority of the complaints alleged the passenger air bag status light stays on (i.e., indicating passenger air bag is turned off) for adult front passengers of sufficient weight.Many of the complaints stated the dealers have made multiple repairs but the problem still persists.In its June 2015 response to ODI's information request under the Recall Query, Nissan provided approximately 1,121 complaints and field reports on the recalled vehicles.These reports alleged OCS issues similar to the NHTSA reports described above.At this time, NHTSA has received a total of approximately 208 complaints (note: total of 1,271 reports shown in the table above eliminates 58 duplicative reports received by ODI and manufacturer).This Recall Q…