2015 Ford F-150 recalls and problems

On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers repo…

On March 21, 2025, NHTSA’s Office of Defects Investigation (ODI) opened this Preliminary Evaluation (PE25002) to investigate instances of unexpected transmission downshifting without driver input in model year (MY) 2015-2017 Ford F-150 vehicles (subject vehicles) manufactured by Ford Motor Company (Ford). The complaints allege that, without warning or driver input, the subject vehicles experienced a sudden and rapid deceleration often accompanied by temporary rear wheel lockup, seizure, or skidding, resulting in a loss of vehicle control that increases the risk of crash and injury to all motorists, including those not within the subject vehicles. The MY 2015 and MY 2016 F-150 vehicles were equipped with the “6R80” transmission, while the MY 2017 vehicles were equipped with either the “6R80” transmission or the “10R80” transmission. This investigation was limited to MY 2015-2017 Ford F-150 with the “6R80” transmission. ODI identified 329 Vehicle Owners Questionnaires (VOQs) related to this investigation and sixty percent of these consumers were interviewed to confirm the details of their allegations. Consumers reported that their vehicles’ transmission suddenly downshifted to a lower gear, often to 1st or 2nd gear, without driver input or advance warning. Consumers described the downshift events to be regular and repeated occurrences, with some consumers stating that they no longer drive the vehicle due to safety concerns. Forty-three percent of consumers r…

On June 18, 2018, the Office of Defects Investigations (ODI) opened a Preliminary Evaluation (PE18-008) to investigate complaints alleging post-crash fires at the B pillar in the area of the seat belt pretensioners on MY 2014-2018 Ford F-150 Regular Cab, and Super Crew Cab Vehicles. On August 24, 2018, Ford Motor Company recalled (FSA 18S27 - NHTSA #18V568) the affected population. Ford's investigation found that some front seat belt pretensioners may generate sparks during deployment in excess of Ford's specification. Sparks in the pretensioner exhaust gases inside the lower portion of the B-pillar may subsequently ignite combustible components contained in the B-pillar, such as insulation or carpet, and may cause a subsequent vehicle fire. ODI also requested relevant information from other manufacturers to assess the potential scope of post-crash pretensioner fires. Ford will notify owners and require dealers to remove B-pillar insulation material and wiring harness tape, and install heat resistant tape, free of charge. The recall notification began September 28, 2018.Owners may contact Ford customer service at 1-866-436-7332.The VOQs associated with the closing of this investigation are: 11143035, 11130056, 11129828, 11128761, 11127993, 11127880, 11124717, 11123419, 11119651, 11119626, 11114065, 11113160, 11111822, 11097937, 11078447, 11014688

NHTSA opened AQ17-001 to determine whether Champion Ford Edinboro, Inc. (Champion Ford), of Edinboro, Pennsylvania, complied with the requirements of the National Traffic and Motor Vehicle Safety Act, 49 U.S.C. Chapter 301 (Safety Act) and its implementing regulations. The Safety Act requires, among other things, that a manufacturer notify its dealers of defects related to motor vehicle safety and non-compliances with Federal Motor Vehicle Safety Standards and, in turn, that a dealer not sell a new vehicle subject to a recall unless the recall remedy has been performed (49 U.S.C. ?30120(i)).NHTSA issued an information request (IR) letter to Champion Ford on January 4, 2017.Champion Ford responded to this request on January 19, 2017.Also on January 4, 2017, an IR letter was issued to Ford Motor Company (Ford) and a response was received from Ford on January 25, 2017.Finally, another IR was issued to Champion Ford on May 31, 2017, and Champion Ford's response letter was submitted to NHTSA on June 14, 2017.NHTSA's investigation indicated that Champion Ford did sell and deliver recalled vehicles that did not have the recall remedy completed at the time the vehicles were delivered to the customers.NHTSA therefore concluded that Champion Ford was liable for civil penalties for violations of the Safety Act, pursuant to 49 U.S.C. ?30165.Under a Settlement Agreement dated April 16, 2018, Champion Ford agreed to pay compromised civil penalties in the amount of $20,000.Champion Ford als…

On June 8, 2020, Ford Motor Company issued a safety recall (NHTSA Recall No. 20V-332) of 292,311 model year (MY) 2014-2017 Ford F-150 vehicles equipped with 3.5L Ecoboost engines and built from 9/1/2014 to 8/1/2016. Ford stated that the causes of brake fluid loss in the master cylinder are brake fluid contamination that can interfere with rear cup seal function, and rolling of the rearmost cup seal.Prior to total loss of the front brakes, depending on the amount of brake fluid loss in the master cylinder, the driver may receive an audible chime, message center alert and red brake warning indicator in the instrument cluster, and may experience a change in brake pedal travel and increased pedal effort. It should be noted that a small number of late-built MY 2014 and early-built MY 2017 F-150 vehicles are included in the recall along with the subject vehicles (MY 2015-2016).This Recall Query is closed based on the safety recall issued by Ford. The ODI reports cited above can be viewed at NHTSA.gov under the following ID numbers:10734951 10839988 10862418 10872737 10873438 10876359 10881590 10883442 10885352 10888026 10888524 10891826 10891829 10891886 10893632 10894688 10894844 10896122 10896446 10898079 10899093 10899198 10902944 10903776 10904695 10908281 10910101 10913678 10913867 10914016 10914164 10914288 10914361 10914382 10914483 10914507 10915027 10915894 10916302 10916346 10916578 10920258 10925699 10926076 10926148 10926179 10927388 10927402 10927459 10927578 10928457 …