2005 Tiffin Allegro recalls and problems

The 2005 Tiffin Allegro has 7 recalls and 2 owner complaints on file with NHTSA; the most reported problem area is exterior lighting.

How the 2005 compares

Low

Fewest complaintsMost complaints

Low complaint count among 23 Allegro model years — 15th most.

7recalls

2complaints

0crashes

1fires

0injuries

34,795median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

7 recalls

Equipment

Feb 8, 2011 · NHTSA campaign 11V082000 · 10,683 vehicles

Problem: Tiffin motorhomes is recalling certain recreational vehicles equipped with 1200-SERIES norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Original NHTSA wording

TIFFIN MOTORHOMES IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak May not shut off in sufficient time to prevent a fire.

Original NHTSA wording

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy & notes

Tiffin motorhomes is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10E-049 for additional information. The safety recall began on February 17, 2011. Owners May contact norcold at 1-800-767-9101.

Owners May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

Equipment

Nov 22, 2010 · NHTSA campaign 10V585000 · 2,717 vehicles

Problem: Tiffin is recalling certain recreational vehicles equipped with 1200-SERIES norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Original NHTSA wording

TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Original NHTSA wording

Remedy & notes

Tiffin is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10E-049 for additional information. The recall began on February 17, 2011. Owners May contact norcold at 1-800-767-9101 or Tiffin at 1-256-356-8661.

Service Brakes

Apr 3, 2009 · NHTSA campaign 09V110000 · 48,876 vehicles

Problem: Navistar is recalling certain model year my 2001-2008 Workhorse W20, W21 and W22 chassis and certain model year 2009 through 2011 monaco RV admiral, arista, monarch, and riptide recreational vehicles equipped with axles that include Bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation May experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver.

Original NHTSA wording

NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.

Risk: The temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.

Original NHTSA wording

THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.

Remedy & notes

Workhorse dealers will replace all four Bosch brake caliper assemblies free of charge. The safety recall began on September 16, 2010. Owners May contact Workhorse at 1-877-246-7731.

Workhorse recall no. 50901-C and 51101-C.owners May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

Equipment

Oct 7, 2008 · NHTSA campaign 08V509000 · 3,507 vehicles

Problem: Tiffin is recalling 3,507 my 2004-2007 allegro, allegro bay and allero bus, my 2004-2005 phaeton and my 2005-2007 zephyr motor homes equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator May have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Original NHTSA wording

TIFFIN IS RECALLING 3,507 MY 2004-2007 ALLEGRO, ALLEGRO BAY AND ALLERO BUS, MY 2004-2005 PHAETON AND MY 2005-2007 ZEPHYR MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Risk: Release of coolant under certain conditions could ignite and result in a fire.

Original NHTSA wording

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy & notes

Tiffin will be working with dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle INC. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners May contact dometic/stericycle at 1-888-446-5157 or Tiffin at 256-356-8661.

Customers May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

Electrical System

Apr 28, 2006 · NHTSA campaign 06V142000 · 1,594 vehicles

Problem: Certain motor homes built on Workhorse chassis and equipped with actia corporate instrument clusters fail to comply with the requirements of federal motor vehicle safety standard no. 101, controls and displays, and no. 105, hydraulic and electric brake systems. If the brake fail input falls below a voltage of 1.5V, the brake failure lamp and alarm will be activated. Also activation of the ABS telltale when the ABS is not properly functioning does not always occur.

Original NHTSA wording

CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 101, CONTROLS AND DISPLAYS, AND NO. 105, HYDRAULIC AND ELECTRIC BRAKE SYSTEMS. IF THE BRAKE FAIL INPUT FALLS BELOW A VOLTAGE OF 1.5V, THE BRAKE FAILURE LAMP AND ALARM WILL BE ACTIVATED. ALSO ACTIVATION OF THE ABS TELLTALE WHEN THE ABS IS NOT PROPERLY FUNCTIONING DOES NOT ALWAYS OCCUR.

Risk: At night the instrument cluster lights May fail and the driver May not be able to see the instrument panel gauges and the brake warning light indicator which could increasing the risk of a crash.

Original NHTSA wording

AT NIGHT THE INSTRUMENT CLUSTER LIGHTS MAY FAIL AND THE DRIVER MAY NOT BE ABLE TO SEE THE INSTRUMENT PANEL GAUGES AND THE BRAKE WARNING LIGHT INDICATOR WHICH COULD INCREASING THE RISK OF A CRASH.

Remedy & notes

Tiffin is working with Workhorse to contact the owners and remedy this campaign . Workhorse will reprogram the instrument panel cluster free of charge. Owners May contact Workhorse at 1-877-246-7731 or Tiffin at 1-256-356-0205.

Customers May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

Electrical System

Jul 5, 2005 · NHTSA campaign 05V307000 · 265 vehicles

Problem: On certain motor homes containing a 50 amp transfer switch built by intellitec, the material used for the wire lugs was changed from nickel plated to copper lugs. The copper lugs are softer than the nickel plated and do not retain the torque of the screw that clamps the wire connector.

Original NHTSA wording

ON CERTAIN MOTOR HOMES CONTAINING A 50 AMP TRANSFER SWITCH BUILT BY INTELLITEC, THE MATERIAL USED FOR THE WIRE LUGS WAS CHANGED FROM NICKEL PLATED TO COPPER LUGS. THE COPPER LUGS ARE SOFTER THAN THE NICKEL PLATED AND DO NOT RETAIN THE TORQUE OF THE SCREW THAT CLAMPS THE WIRE CONNECTOR.

Risk: When the torque is relaxed, the lugs can become loose resulting in excessive heat within the connected wire that could result in a fire.

Original NHTSA wording

WHEN THE TORQUE IS RELAXED, THE LUGS CAN BECOME LOOSE RESULTING IN EXCESSIVE HEAT WITHIN THE CONNECTED WIRE THAT COULD RESULT IN A FIRE.

Remedy & notes

Dealers will replace the changeover box. The recall began on July 21, 2005. Owners May contact Tiffin at 1-256-356-8661.

Customers May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

Seat Belts

Aug 3, 2004 · NHTSA campaign 04V383000 · 1,662 vehicles

Problem: The seat belt assemblies on certain motor homes fail to comply with the loop load requirements of federal motor vehicle safety standard no. 209. "seat belt assemblies."

Original NHTSA wording

THE SEAT BELT ASSEMBLIES ON CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE LOOP LOAD REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209. "SEAT BELT ASSEMBLIES."

Risk: The seat belt buckle May unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.

Original NHTSA wording

THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Remedy & notes

Amsafe will replace the buckles. Owners should contact amsafe at 574-266-8330 or Tiffin at 1-256-356-8661.

Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Recall text as published by NHTSA and the manufacturer.

What owners complain about

Exterior Lighting1

Service Brakes1

Owner complaints filed with NHTSA; one complaint can name several areas. Not verified by NHTSA.

2005 vs. other Tiffin Allegro years

Owner complaints by model year; the darker bar is the 2005. Click a bar to switch year.

Questions

Does the 2005 Tiffin Allegro have recalls?

Yes — NHTSA lists 7 recall campaigns covering the 2005 Tiffin Allegro, the latest from Feb 8, 2011 (equipment). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2005 Tiffin Allegro?

Owner complaints filed with NHTSA most often mention exterior lighting (1), service brakes (1). Complaints are consumer reports and are not verified by NHTSA.