2007 Peterbilt 387 recalls and problems

The 2007 Peterbilt 387 has 6 recalls and 0 owner complaints on file with NHTSA.

How the 2007 compares

Too few model years with complaints to compare.

6recalls

0complaints

0crashes

0fires

0injuries

—median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

6 recalls

Equipment

Mar 6, 2015 · NHTSA campaign 15V132000 · 213,230 vehicles

Problem: PACCAR Incorporated (PACCAR) is recalling certain model year 2006-2016 Peterbilt 587, 579, 567, 389, 388, 387, 385, 382, 379, 378, 367, 365 and 357 trucks manufactured July 25, 2005, to February 26, 2016. The affected vehicles may be equipped with Tire and Rim Certification Labels that list a tire pressure below the actual correct amount. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard No. 120, "Tire selection and rims and motor home/recreation vehicle trailer load carrying capacity information for motor vehicles with a GVWR of more than 4,536 kilograms (10,000 pounds)."

Risk: If the tires are underinflated due to the incorrect inflation pressure listed on the label, the truck may not be able to carry the maximum gross vehicle weight rating (GVWR) load listed without experiencing tire failure which would increase the risk of a crash.

Remedy & notes

Peterbilt will notify owners and mail them a corrected Tire and Rim certification label, free of charge. The recall began on June 19, 2015. Owners may contact Peterbilt customer service at 1-940-591-4000. PACCAR's number for this recall is 215-D.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Fuel System

Feb 23, 2011 · NHTSA campaign 11V127000 · 4,664 vehicles

Problem: Paccar is recalling certain model year 2008-2012 Kenworth T2000, T660, T700, T800, and W900, as well as model year 2009-2012 Peterbilt 365, 367, 384, 386, 387, 388, 389, and 587 trucks equipped with paccar mx engines. The oil module centrifugal spinner filter cap in the paccar mx engine May become loose, possibly allowing the cap to come off and engine oil to partially discharge from the oil module onto exhaust components.

Original NHTSA wording

PACCAR IS RECALLING CERTAIN MODEL YEAR 2008-2012 KENWORTH T2000, T660, T700, T800, AND W900, AS WELL AS MODEL YEAR 2009-2012 PETERBILT 365, 367, 384, 386, 387, 388, 389, AND 587 TRUCKS EQUIPPED WITH PACCAR MX ENGINES. THE OIL MODULE CENTRIFUGAL SPINNER FILTER CAP IN THE PACCAR MX ENGINE MAY BECOME LOOSE, POSSIBLY ALLOWING THE CAP TO COME OFF AND ENGINE OIL TO PARTIALLY DISCHARGE FROM THE OIL MODULE ONTO EXHAUST COMPONENTS.

Risk: The discharge of engine oil onto exhaust components which are hot, such as when the engine is under significant load, May cause a fire.

Original NHTSA wording

THE DISCHARGE OF ENGINE OIL ONTO EXHAUST COMPONENTS WHICH ARE HOT, SUCH AS WHEN THE ENGINE IS UNDER SIGNIFICANT LOAD, MAY CAUSE A FIRE.

Remedy & notes

Dealers will re-torque the oil module filter cap and install a secondary retention device on the secondary centrifugal spinner filter cap. This service will be performed free of charge. The safety recall is expected to begin during March 2011. Owners May contact Kenworth at 1-425-828-5440 and Peterbilt at 1-940-591-4196.

Owners May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

Power Train

Dec 13, 2010 · NHTSA campaign 10V634000 · 12,873 vehicles

Problem: Paccar is recalling certain model year 2007-2008 Kenworth and Peterbilt vehicles manufactured from February 2, 2006 through April 30, 2007. The bearing surfaces of the extended lube universal joint that attaches the inter-axle driveline to the drive axle May become prematurely worn due to breakdown of lubrication and/or excessive heat. Prematurely worn bearing surfaces May result in the u-joint becoming loose and/or binding. This condition May result in universal joint failure, allowing the inter-axle driveline to detach from the axle.

Original NHTSA wording

PACCAR IS RECALLING CERTAIN MODEL YEAR 2007-2008 KENWORTH AND PETERBILT VEHICLES MANUFACTURED FROM FEBRUARY 2, 2006 THROUGH APRIL 30, 2007. THE BEARING SURFACES OF THE EXTENDED LUBE UNIVERSAL JOINT THAT ATTACHES THE INTER-AXLE DRIVELINE TO THE DRIVE AXLE MAY BECOME PREMATURELY WORN DUE TO BREAKDOWN OF LUBRICATION AND/OR EXCESSIVE HEAT. PREMATURELY WORN BEARING SURFACES MAY RESULT IN THE U-JOINT BECOMING LOOSE AND/OR BINDING. THIS CONDITION MAY RESULT IN UNIVERSAL JOINT FAILURE, ALLOWING THE INTER-AXLE DRIVELINE TO DETACH FROM THE AXLE.

Risk: Detachment of the driveline from the axle May cause the vehicle to lose power and become disabled in the roadway. Also, the driveline could drop from the vehicle into the roadway increasing the risk of a crash.

Original NHTSA wording

DETACHMENT OF THE DRIVELINE FROM THE AXLE MAY CAUSE THE VEHICLE TO LOSE POWER AND BECOME DISABLED IN THE ROADWAY. ALSO, THE DRIVELINE COULD DROP FROM THE VEHICLE INTO THE ROADWAY INCREASING THE RISK OF A CRASH.

Remedy & notes

Paccar is working with its supplier to remedy the vehicles free of charge. The safety recall is expected to begin during February 2011. Owners May contact Kenworth at 425-828-5440 and Peterbilt at 940-591-4196.

Kenworth recall no. 10KWL & Peterbilt recall no. 1201F.owners May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

Engine

Jan 16, 2009 · NHTSA campaign 09V019000 · 1,098 vehicles

Problem: Paccar is recalling 1098 Kenworth my 2008 T800, W900, my 2008-2009 T2000 and Peterbilt my 2007-2009 379 and 387 trucks equipped with C15 caterpillar diesel engines. The aftertreatment regeneration device (ard) May develop a hole and heat and flame May escape during a regeneration of the diesel particulate filter.

Original NHTSA wording

PACCAR IS RECALLING 1098 KENWORTH MY 2008 T800, W900, MY 2008-2009 T2000 AND PETERBILT MY 2007-2009 379 AND 387 TRUCKS EQUIPPED WITH C15 CATERPILLAR DIESEL ENGINES. THE AFTERTREATMENT REGENERATION DEVICE (ARD) MAY DEVELOP A HOLE AND HEAT AND FLAME MAY ESCAPE DURING A REGENERATION OF THE DIESEL PARTICULATE FILTER.

Risk: This May result in a fire hazard.

Original NHTSA wording

THIS MAY RESULT IN A FIRE HAZARD.

Remedy & notes

Paccar is working with caterpillar and will inspect and remedy the engines free of charge. Owners May contact caterpillar at 1-800-447-4986, Kenworth at 425-828-5440 or Peterbilt at 940-591-4196.

Kenworth recall no. 09KW1 & Peterbilt recall no. 108A.customers May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

Power Train

Mar 22, 2007 · NHTSA campaign 07V132000 · 245 vehicles

Problem: On certain trucks, the axle housings May have been manufactured with steel that was out of specification which could result in a fatigue failure over time.

Original NHTSA wording

ON CERTAIN TRUCKS, THE AXLE HOUSINGS MAY HAVE BEEN MANUFACTURED WITH STEEL THAT WAS OUT OF SPECIFICATION WHICH COULD RESULT IN A FATIGUE FAILURE OVER TIME.

Risk: If a fatigue failure occurs and is left unattended, the axle May lock up or the end of the axle could come off, which May result in a vehicle crash.

Original NHTSA wording

IF A FATIGUE FAILURE OCCURS AND IS LEFT UNATTENDED, THE AXLE MAY LOCK UP OR THE END OF THE AXLE COULD COME OFF, WHICH MAY RESULT IN A VEHICLE CRASH.

Remedy & notes

Dealers will inspect and replace the axles free of charge. The recall began on May 9, 2007. Owners May contact Kenworth at 425-828-5440 and Peterbilt at 1-940-591-4196.

Kenworth recall no. 07KW4 & Peterbilt recall no. 107C.customers May contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

Suspension

Dec 21, 2006 · NHTSA campaign 06V490000 · 3,246 vehicles

Problem: On some Peterbilt trucks, certain parts used in the air suspensions have a high copper content causing premature failure.

Original NHTSA wording

ON SOME PETERBILT TRUCKS, CERTAIN PARTS USED IN THE AIR SUSPENSIONS HAVE A HIGH COPPER CONTENT CAUSING PREMATURE FAILURE.

Risk: Failure could cause erratic vehicle handling which can cause a vehicle crash without warning.

Original NHTSA wording

FAILURE COULD CAUSE ERRATIC VEHICLE HANDLING WHICH CAN CAUSE A VEHICLE CRASH WITHOUT WARNING.

Remedy & notes

Dealers will inspect and, when necessary, replace the defective parts. The recall began on January 17, 2007. Owners May contact Peterbilt at 1-940-591-4196.

Paccar/Peterbilt recall no. 1206D.customers May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

Recall text as published by NHTSA and the manufacturer.

NHTSA investigations

Driveshaft separates from tractor

PE10029 · opened Aug 2, 2010 · closed Dec 23, 2010 · led to recall 10V634000

Summary

SummaryOn July 13, 2010, the Office of Defects Investigations (ODI) opened an investigation on model year (MY) 2007-2009 Peterbilt tractors equipped with the (SPL170XL extended lube inter-axle driveline).ODI opened this investigation based on one Vehicle Owners Questionnaire (VOQ) and certain Peterbilt field reports.During the course of the investigation, ODI reviewed PACCAR's IR (October 22, 2010) response with associated data related to Warranty and complaint information, mined field data, interviewed customers and visited local dealers within the Washington Metropolitan area.PACCARconducted testing regarding torsional loading and identified various causative factors contributed to this safety defect finding.The Defect is a consequence of the bearing surfaces of the SPL170XL extended lube universal joint that attaches the inter-axle driveline to the drive axle becoming prematurely worn due to a breakdown of lubrication and/or excessive heat.Prematurely worn bearing surfaces may result in the u-joint becoming loose and/or binding.This condition may result in universal joint failure, allowing the inter-axle driveline to detach from the axle, which may cause the drive shaft to separate from the vehicle, increasing the risk of personal injury or property damage hazard.ODI learned that the affected population of the alleged defect extended to peer models within PACCAR.In summary, the following vehicles are being recalled: MY 2007 and 2008 Kenworth trucks, models T600, T660, T200…

Horton Fan Hub Failures

EA09008 · opened May 29, 2009 · closed Aug 27, 2010

Summary

PACCAR is conducting an Owner Notification Program (ONP) for select vehicles within the subject and peer populations.The ONP are attached to the closing report and can be found in the NHTSA Technical Service Bulletin (TSB) database. (TSB: 10033585, 10033584)See Closing report for investigation details.

REAR BRAKE AIR CHAMBER MTG BRACKETS

PE09013 · opened Feb 27, 2009 · closed Jul 6, 2009

Summary

ON JUNE 23, 2009 PACCAR NOTIFIED ODI THAT 3,423 KENWORTH T2000, T800, T600, W900, AND T660 TRUCKS, MODEL YEARS 2004 - 2009, EQUIPPED WITH BENDIX BRAKES, WIDE BASE LOW PROFILE TIRES AND AIRGLIDE (AG) 400/460 REAR SUSPENSIONS ARE BEING RECALLED.CERTAIN OF THESE VEHICLES HAVE EXPERIENCED FATIGUE CRACKS IN THE BRAKE CAM TUBE MOUNTING OR AIR CHAMBER MOUNTING FLANGES BRACKET ADJACENT TO THE ATTACHMENT WELDS. IF LEFT UNREPAIRED, THE CRACKS CAN CAUSE A COMPLETE FRACTURE OF THE CAM TUBE, WHICH COULD DISABLE THE AFFECTED BRAKE AND RISK INCREASING VEHICLE STOPPING DISTANCES UNDER HIGH PRESSURE BRAKE APPLICATIONS AND DECREASE PARKING BRAKE CAPABILITY.THIS CONFIGURATION HAS EXPERIENCED FAILURES AT A HIGHER RATE THAN SIMILAR VEHICLES WITH OTHER TYPES OF SUSPENSIONS AND BRAKE INSTALLATION CLOCKING. PACCAR WILL ALSO SEND AN OWNER NOTIFICATION LETTER TO OWNERS OF VEHICLES EQUIPPED WITH SUSPENSIONS OTHER THAN THE AG 400/460, WHICH WILL PRESCRIBE A PERIODIC INSPECTION OF THE COMPONENTS AND IF A CRACK IS DISCOVERED, OFFER THE OWNERS THE OPPORTUNITY FOR A FREE REPAIR.THIS POLICY WILL BE IN EFFECT UNTIL JULY 15, 2014. COPIES OF THE RECALL AND THE OWNER NOTIFICATION ARE ATTACHED.

HORTON FAN HUB FAILURES

PE09002 · opened Jan 5, 2009 · closed May 29, 2009

Summary

THERE ARE 84,573 SUBJECT AND PEER (KENWORTH) VEHICLES.SUBJECT VEHICLES ARE MODEL YEAR 2007 THROUGH 2008 PACCAR TRUCKS BUILT WITH A HORTON FAN HUB ASSEMBLY.THE EA WILL INCLUDE PEER VEHICLES (KENWORTH'S WITH HORTON FAN HUBS) IN THE SUBJECT POPULATION.THERE ARE A TOTAL OF 1,645 WARRANTY CLAIMS ON THE COMBINED POPULATION.ODI SURVEYED WARRANTY CLAIM OWNERS AND FOUND THAT A SIGNIFICANT NUMBER OF THE FAILURES RESULTED IN A DISABLED VEHICLE.ODI ALSO BELIEVES THAT CERTAIN MODELS ARE MORE PRONE TO FAILURE AND FURTHER ANALYSIS IS WARRANTED TO UNDERSTAND THE DIFFERENCES IN FAILURE RATES. ODI IS CONCERNED THAT A LARGE DISABLED VEHICLE IS AT AN INCREASED RISK OF BEING STRUCK IN THE REAR BY ANOTHER VEHICLE.ODI IS ALSO CONCERNED THAT THIS FAILURE MODE PROVIDES LITTLE WARNING AND THEREFORE, A DRIVER HAS LESS OPPORTUNITY TO REMOVE THE VEHICLE FROM THE TRAVEL LANES OR SHOULDER, ONCE A FAN SEPARATION HAS OCCURRED.ODI WILL CONDUCT FURTHER RISK ASSESSMENT DURING THE EA TO GAIN AN UNDERSTANDING OF THE WARNING, OPTIONS AVAILABLE TO THE DRIVER AND THE INCREASED RISK OF THE TRUCK BEING STRUCK IN THE EVENT OF A BREAKDOWN.NHTSA HAS UPGRADED PE09-002 TO AN EA (EA09-008) TO FURTHER INVESTIGATE THIS MATTER.

2007 vs. other Peterbilt 387 years

Owner complaints by model year; the darker bar is the 2007. Click a bar to switch year.

Questions

Does the 2007 Peterbilt 387 have recalls?

Yes — NHTSA lists 6 recall campaigns covering the 2007 Peterbilt 387, the latest from Mar 6, 2015 (equipment). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2007 Peterbilt 387?

Few complaints have been filed with NHTSA for the 2007 Peterbilt 387.