2001 Volvo Wxll recalls and problems

The 2001 Volvo Wxll has 3 recalls and 0 owner complaints on file with NHTSA.

How the 2001 compares

Too few model years with complaints to compare.

3recalls

0complaints

0crashes

0fires

0injuries

—median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

3 recalls

Power Train

Aug 22, 2003 · NHTSA campaign 03V308000 · 3,426 vehicles

Problem: On certain heavy-duty class 8 vehicles, the body builder wiring option was mis-wired in such a way that the auto neutral with service brake status option May allow the transmission to go into forward gear without the driver's foot pressing down on the brake pedal first.

Original NHTSA wording

ON CERTAIN HEAVY-DUTY CLASS 8 VEHICLES, THE BODY BUILDER WIRING OPTION WAS MIS-WIRED IN SUCH A WAY THAT THE AUTO NEUTRAL WITH SERVICE BRAKE STATUS OPTION MAY ALLOW THE TRANSMISSION TO GO INTO FORWARD GEAR WITHOUT THE DRIVER'S FOOT PRESSING DOWN ON THE BRAKE PEDAL FIRST.

Risk: Unintended movement of the vehicle could put persons in danger inside and outside the vehicle.

Original NHTSA wording

UNINTENDED MOVEMENT OF THE VEHICLE COULD PUT PERSONS IN DANGER INSIDE AND OUTSIDE THE VEHICLE.

Remedy & notes

Volvo trucks will notify its customers and install an additional air operated stop light switch and the necessary wiring changes. Owner notification is expected to begin during September 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact at 1-800-528-6586.

Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Engine

May 15, 2003 · NHTSA campaign 03V183000 · 120 vehicles

Problem: On certain transit buses equipped with cummins westport b gas plus or c gas plus 6 cylinder engines, the electronic control module calibration May not correctly detect a throttle plate actuator failure that could result in an uncommanded open throttle condition.

Original NHTSA wording

ON CERTAIN TRANSIT BUSES EQUIPPED WITH CUMMINS WESTPORT B GAS PLUS OR C GAS PLUS 6 CYLINDER ENGINES, THE ELECTRONIC CONTROL MODULE CALIBRATION MAY NOT CORRECTLY DETECT A THROTTLE PLATE ACTUATOR FAILURE THAT COULD RESULT IN AN UNCOMMANDED OPEN THROTTLE CONDITION.

Risk: If this event occurs, the vehicle operator will not have control of the engine speed which could possibly result in a vehicle crash.

Original NHTSA wording

IF THIS EVENT OCCURS, THE VEHICLE OPERATOR WILL NOT HAVE CONTROL OF THE ENGINE SPEED WHICH COULD POSSIBLY RESULT IN A VEHICLE CRASH.

Remedy & notes

Dealers will replace the electronic control module calibration free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cummins customer assistance center at 1-800-343-7357 or Volvo truck at 1-800-528-6586.

Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Power Train

Feb 5, 2002 · NHTSA campaign 02V036000 · 215 vehicles

Problem: On certain heavy duty class 8 trucks, the forward and/or rear drive axle upper axle seat can break allowing the axle to shift out of alignment.

Original NHTSA wording

ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS, THE FORWARD AND/OR REAR DRIVE AXLE UPPER AXLE SEAT CAN BREAK ALLOWING THE AXLE TO SHIFT OUT OF ALIGNMENT.

Risk: This could result in a loss of axle stability increasing the risk of a crash.

Original NHTSA wording

THIS COULD RESULT IN A LOSS OF AXLE STABILITY INCREASING THE RISK OF A CRASH.

Remedy & notes

Dealers will inspect the upper axle seat for a certain date code that is stamped on the part, and those axles will be replaced. Owner notification began March 15, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact Volvo trucks at 1-800-528-6586.

Also contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Recall text as published by NHTSA and the manufacturer.

2001 vs. other Volvo Wxll years

Owner complaints by model year; the darker bar is the 2001. Click a bar to switch year.

Questions

Does the 2001 Volvo Wxll have recalls?

Yes — NHTSA lists 3 recall campaigns covering the 2001 Volvo Wxll, the latest from Aug 22, 2003 (power train). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2001 Volvo Wxll?

Few complaints have been filed with NHTSA for the 2001 Volvo Wxll.