2002 Saturn Vue recalls and problems

ON DECEMBER 12, 2005, ODI RECEIVED A DEFECT PETITION (DP05-008) REQUESTING THE INVESTIGATION OF TIMING CHAIN FAILURES THAT COULD CAUSE STALLING IN SATURN VEHICLES EQUIPPED WITH THE 2.2L (L61) ENGINE. ODI OPENED PE06-006 ON JANUARY 24, 2006, WITH 24 VEHICLE OWNER COMPLAINTS THAT ALLEGED A BROKEN TIMING CHAIN CAUSED THE VEHICLE TO STOP OPERATING.ON APRIL 12, 2006, ODI RECEIVED INFORMATION FROM GENERAL MOTORS (GM) CONCERNING TIMING CHAIN FAILURES IN APPROXIMATELY 412,000 MODEL YEAR (MY) 2000 THROUGH 2003 SATURN L-SERIES AND ION VEHICLES WITH 2.2L ENGINES. GM'S RESPONSE INCLUDED 1,020 OWNER COMPLAINTS AND FIELD REPORTS CONCERNING TIMING CHAIN FAILURE, INCLUDING 228 THAT ALLEGED THE FAILURE CAUSED THE VEHICLE TO STALL WHILE DRIVING.GM ALSO PROVIDED WARRANTY CLAIM DATA THAT SHOWED 1,902 SUBJECT VEHICLES RECEIVING TIMING CHAIN REPAIRS, INCLUDING 261 WHICH INDICATED THAT A STALL WHILE DRIVING RESULTED FROM THE FAILURE.THE GM COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS THAT DID NOT CONTAIN SUFFICIENT INFORMATION TO DETERMINE THAT A STALL WHILE DRIVING OCCURRED WERE PROVIDED IN THE CATEGORY OTHER.GM STATED THAT THE MAJORITY OF THESE INCIDENTS PROBABLY OCCURRED WHILE THE VEHICLES WERE PARKED SINCE THE TIMING CHAIN IS MORE LIKELY TO BREAK DURING HIGH CHAIN LOAD SITUATIONS, SUCH AS ENGINE STARTUP.GM'S DATA SHOWED ELEVATED FAILURE RATES IN APPROXIMATELY 20,500 MY 2001 L-SERIES VEHICLES PRODUCED DURING A FOUR MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001.OVER ONE-THIRD OF GM'S TOT…

THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED THIS PRELIMINARY EVALUATION TO INVESTIGATE ALLEGATIONS OF REAR SUSPENSION FAILURE IN THE SUBJECT VEHICLES DURING CERTAIN SEVERE DRIVING MANEUVERS.THE INVESTIGATION WAS PROMPTED BY NHTSA-CONDUCTED NCAP DYNAMIC ROLLOVER TEST INCIDENTS INVOLVING MY 2004 SATURN VUE VEHICLES AND ONE CONSUMER COMPLAINT THAT ALLEGED WHEN RECOVERING FROM A ROAD EDGE DEPARTURE, THE LEFT-REAR WHEEL OF A MY 2003 SATURN VUE ?BENT UNDERNEATH THE VEHICLE,? RESULTING IN A ROLLOVER CRASH.ODI ANALYSIS INDICATES THAT REAR SUSPENSION FAILURE DURING THE NCAP TESTS WAS THE RESULT OF WHEEL RIM-PAVEMENT CONTACT TRANSMITTING SIGNIFICANT COMPRESSIVE FORCES TO THE TOE CONTROL LINK, THUS CAUSING IT TO BUCKLE.THIS FAILURE OCCURRED AT LOW SPEED DURING A SEVERE TEST USED TO ASSESS ROLL STABILITY.THE FORCES GENERATED DURING THIS TYPE OF WHEEL-RIM PAVEMENT CONTACT ARE MORE THAN SIX TIMES THE GREATEST FORCES MEASURED DURING GM?S MOST SEVERE VEHICLE DEVELOPMENT AND VALIDATION TESTING.ODI INSPECTION AND ANALYSIS OF CONSUMER COMPLAINT VEHICLES SHOWED THAT DAMAGE TO THE TOE CONTROL LINK APPEARED TO BE THE RESULT OF VEHICLE CRASHES AND DID NOT PRECIPITATE THE CRASHES.TO DATE, ODI IS AWARE OF NO VEHICLE CRASHES OR ROLLOVER INCIDENTS RELATED TO THE ALLEGED DEFECT.ADDITIONALLY, THE MANUFACTURER HAS NOTIFIED THE AGENCY THAT IT IS CONDUCTING A VOLUNTARY CUSTOMER SATISFACTION SERVICE CAMPAIGN TO STRENGTHEN THE REAR SUSPENSION OF THE SUBJECT VEHICLES.A SAFETY-RELATED DEFECT HAS NOT BEEN I…