2025 Peterbilt 537 recalls and problems

The 2025 Peterbilt 537 has 6 recalls and 1 owner complaint on file with NHTSA; the most reported problem area is visibility.

Do not drive warning. NHTSA and the manufacturer advise owners not to drive affected vehicles until the recall repair is done. Affected campaign: 24V433000.

How the 2025 compares

Too few model years with complaints to compare.

6recalls

1complaints

0crashes

0fires

0injuries

—median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

6 recalls

Fuel System

Oct 21, 2026 · NHTSA campaign 26V700000 · 26,729 vehicles

Problem: PACCAR Incorporated (PACCAR) is recalling certain 2022-2023 Kenworth T370, T270, 2022-2027 Kenworth T280, Peterbilt 548, 2023-2027 Kenworth T480, T380, Peterbilt 536, 537, and 2025 Peterbilt 567 vehicles. The remote fuel filter hoses may separate from the fitting, causing a fuel leak and an engine stall.

Risk: A fuel leak in the presence of an ignition source increases the risk of a fire. An engine stall increases the risk of a crash.

Remedy

Dealers will replace the fuel hoses, free of charge. Owner notification letters will be mailed beginning December 20, 2026. Owners may contact Peterbilt's customer service at 1-940-591-4220 or Kenworth's customer service at 1-425-828-5888. PACCAR's number for this recall is 26PACJ.

Exterior Lighting

Jun 26, 2025 · NHTSA campaign 25V436000 · 56,260 vehicles

Problem: PACCAR Incorporated (PACCAR) is recalling certain 2024-2026 Kenworth T480, T680, T880, W990, Peterbilt 520, 536, 537, 548, 567, 579, 589, 2025 Kenworth T180, Peterbilt 535, 2025-2026 Kenworth T280, T380 and L770 vehicles. The tail brake light, upper and lower beam headlights, reverse light, and turn signal may not illuminate as intended. In addition, the lift axles, if lowered, may revert to a raised position, or oscillate up and down when the signal warning lights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."

Risk: Delayed and unsteady headlights can result in insufficient illumination of the road, decreasing the driver's visibility and increasing the risk of a crash. In addition, an unexpected position change of the lift axles may increase the risk of injury.

Remedy

Dealers will update the VCU software, free of charge. Owner letters were mailed August 19, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's number for this recall is 25PACF.

Electrical System

Jan 29, 2025 · NHTSA campaign 25V041000 · 5,378 vehicles

Problem: PACCAR Incorporated (PACCAR) is recalling certain 2025 Kenworth T180, Peterbilt 535, 567, 2025-2026 Kenworth T280, 2023-2026 Kenworth T380, 2024-2026 Kenworth T480, 2024-2026 Peterbilt 536, 537, and 548 trucks. The exterior lighting switch may fail, resulting in the hazard lights and the instrument display back-light brightness adjustment not functioning. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 101, "Control and Displays" and 108, "Lamps, Reflective Devices and Associated Equipment."

Risk: Inoperative hazard lights cannot alert other drivers as intended. In addition, the inability to adjust the brightness on the instrument panel display can make it difficult to see critical safety information or distract the driver. Both scenarios can increase the risk of a crash.

Remedy & notes

Dealers will update the vehicle cab controller unit (VECU) software, free of charge. Owners are advised that a non-responsive switch can be temporarily reset by a key cycle. Owner notification letters were mailed March 26, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 25KWB and 25PBB.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.

Electrical System

Dec 9, 2024 · NHTSA campaign 24V915000 · 220,764 vehicles

Problem: PACCAR Incorporated (PACCAR) is recalling certain 2021-2025 Peterbilt and Kenworth vehicles, equipped with Bendix EC80 Advanced Electronic Control Units (ECU). Please see the recall report for a complete list of models. Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop functioning.

Risk: Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may not function properly or at all, increasing the risk of a crash.

Remedy & notes

Dealers will reprogram the ECU software, free of charge. Owner notification letters were mailed February 3, 2025. Owners may contact Kenworth's customer service at 1-425-828-5888 and Peterbilt's customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWL and 24PBL.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.

Steering

Jun 12, 2024 · NHTSA campaign 24V433000 · 7,410 vehicles

Do not drive

Problem: PACCAR Incorporated (PACCAR) is recalling certain 2025 Kenworth K270, K370, L770, T280, T380, T480, T680, T880, W900, W990, 2025 Peterbilt 220, 520, 536, 537, 548, 567, 579, and 589 trucks. The tie rod or drag link assembly may contain an improperly heat-treated ball stud, causing the ball stud to break.

Risk: A broken ball stud can cause a complete loss of steering control, increasing the risk of a crash.

Remedy & notes

Owners are advised not to drive their vehicles until the remedy has been completed. Dealers will inspect and replace the tie rod and drag link assemblies as necessary, free of charge. Owner notification letters were mailed August 6, 2024. Owners may contact Kenworth customer service at 1-425-828-5888 and Peterbilt customer service at 1-940-591-4220. PACCAR's numbers for this recall are 24KWG and 24PBG.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Steering

Jan 25, 2024 · NHTSA campaign 24V044000 · 45,887 vehicles

Problem: PACCAR Incorporated (PACCAR) is recalling certain 2024-2025 Kenworth T280, T380, T480, T680, T880, L770, W990, and 2024-2025 Peterbilt 389, 520, 535, 536, 537, 548, 567, 579, 589 trucks. The steering gear assemblies may have been assembled incorrectly with fewer recirculating balls than are required, which may result in a loss of steering control.

Risk: A loss of steering control increases the risk of a crash.

Remedy & notes

Dealers will inspect and replace the steering gears as necessary, free of charge. Owner notification letters were mailed March 20, 2024. Owners may contact Peterbilt customer service at 1-940-591-4220 and/or Kenworth customer service at 1-425-828-5888. PACCAR's numbers for this recall are 24PBC and 24KWC.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Recall text as published by NHTSA and the manufacturer.

What owners complain about

Visibility1

Owner complaints filed with NHTSA; one complaint can name several areas. Not verified by NHTSA.

2025 vs. other Peterbilt 537 years

Owner complaints by model year; the darker bar is the 2025. Click a bar to switch year.

Questions

Does the 2025 Peterbilt 537 have recalls?

Yes — NHTSA lists 6 recall campaigns covering the 2025 Peterbilt 537, the latest from Oct 21, 2026 (fuel system). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2025 Peterbilt 537?

Owner complaints filed with NHTSA most often mention visibility (1). Complaints are consumer reports and are not verified by NHTSA.

Is it safe to drive the 2025 Peterbilt 537?

1 recall for this model year carries a "Do Not Drive" advisory. Only vehicles with the recall open are affected — check your VIN at nhtsa.gov/recalls.