2011 Nissan Leaf recalls and problems

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

Preliminary Evaluation (PE) 19-015 was opened as a result of Defect Petition (DP) 19-002 which alleged that model year (MY) 2011 and 2012 Nissan Leaf were affected by the same defect addressed in an earlier recall, NHTSA Safety Recall 16V-244, but were not included in the scope of that recall.NHTSA 16V-244 involved a defect in the Occupant Classification System, a system intended to suppress deployment of the passenger's frontal air bag under certain specific conditions. Although the DP19-002 analysis determined the allegation that earlier MY Leaf vehicles should have been included in 16V-244 was not founded, the Office of Defects Investigation nonetheless granted the petition and commenced this investigation into the 2011 and 2012 Leaf since OCS failures were reportedly occurring in these vehicles. Further details on DP19-002 can be found at NHTSA.gov.On October 25, 2019, ODI sent an information request letter to Nissan North America (Nissan) requesting pertinent information on the subject 2011 and 2012 Leaf. Nissan provided its response on December 13, 2019. ODI has reviewed the information Nissan provided as well as new reports submitted to NHTSA's Vehicle Owner Questionnaire database. Based on review of all available information, and at this time, ODI has identified evidence supporting that a total of 76 subject vehicles likely experienced a failure of the subject passenger seat OCS mat. The count represents an incidence rate of about 0.4% on subject vehicles that average…

A defect petition (see DP19-002) was received July 23, 2019 alleging that the occupant classification system (OCS) sensor (mat) in model year (MY) 2011 Nissan Leaf vehicles is defective and affects the proper deployment of the passenger front air bag. The petitioner provided a list of potentially related NHTSA reports and noted a Nissan recall involving later MY Leaf vehicles with OCS defect. NHTSA is granting the petition and opening a preliminary evaluation in response, please see PE19-015.Since receiving the defect petition, the Office of Defects Investigation (ODI) has determined that the MY 2011 and 2012 Leaf share a common OCS design, both using the same sensor mat for passenger presence sensing. Starting in MY 2013, Leaf OCS was changed to a design using a different sensing system, one that did not use the mat present in prior model year, Nissan Leaf. While MY 2013-2016 Leaf vehicles were recalled for an OCS defect under recall 16V-244, a recall influenced by ODI investigation EA15-004, earlier MY Leaf vehicles were not included because they were not affected by the particular defect involved in that recall.ODI identified and reviewed 13 vehicle owner questionnaire (VOQ) reports in its database, one of which is a duplicate, involving MY 2011 and 2012 Leaf vehicles that allege a problem with the OCS. The VOQs indicate that an OCS warning light illuminated at which point the vehicle was diagnosed and it was determined the sensor mat was the cause of the OCS problem. Most…