2012 Jeep Liberty recalls and problems

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been n…

The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that in…

The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect.  During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW.  The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications.  The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU.  In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment.  FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle.  Other FCA vehicles…

The Office of Defects Investigation opened this Preliminary Evaluation to investigate VOQ complaints alleging a failure of the Occupant Restraint Controller (ORC) module in model year (MY) 2012 Jeep Liberty.The purpose of the investigation was to understand Vehicle Owner Questionnaire (VOQ) complaints stating that the air bag warning light remained illuminated while the vehicle was in operation.In many cases the warning light issue was reportedly corrected by a replacement of the ORC module. In 2013 FCA issued NHTSA safety recall 13V282 to address ORC module failures caused by an electrical over stress (EOS) condition that damaged an internal resistor.The failure lead to non-deployment of the active head restraints in rear impact crashes of sufficient severity to require deployment.This condition would also result in illumination of the air bag warning light and set a B2208 diagnostic trouble code (DTC).Recall 13V282 involved two different remedies based on the model year and model of the recalled vehicle.Some models were repaired by replacing the ORC with an updated unit.However the subject vehicles of this investigation, which made up the largest population in the recall, received a software update to the Totally Integrated Power Module (TIPM), another electronic device that is involved in powering of the ORC. After the investigation was opened, FCA began collecting failed subject vehicle ORC modules so they could be analyzed for failure causation.From June 2017 to August 2…

In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher compla…

The driver's side power master window switch (PMWS) evaluted during this investigation controls the power windows for all four doors, the power mirrors and door locks.The PMWS is located on the driver's side door panel.Chrysler advised that the PMWS was used on multiple vehicle platforms including model year (MY) 2011 Dodge Nitro, MY 2011-2012 Jeep Liberty and MY 2011 Chrysler Town & Country and Dodge Caravan for a total of approximately 425,000 vehicles.At the opening of the investigation, ODI identified two reports of fire near the vicinity of the PMWS on MY 2012 Jeep Liberty Vehicles.During the course of the investigation, ODI determined that one of the complaint fires was not likely caused by a PMWS failure as available evidence indicated the fire started in the dashboard as opposed to the door panel area.Accordingly, the report was removed from the above counts.In response to ODI's October 30, 2013 information request (IR) letter, Chrysler advised that it was only aware of the same two fire reports as ODI and that it had concluded one of the reports did not involve a PMWS failure.ODI has not identified any new subject vehicle reports involving PMWS fires during the course of the investigation.In addition to the reports alleging fire, ODI evaluated other reports and data related to PMWS failures including consumer complaints, field reports, law suits, and warranty claims provided by Chrysler in its response.ODI interviewed owners of complaint vehicles when additional info…