2005 Itasca Sunflyer recalls and problems

The 2005 Itasca Sunflyer has 3 recalls and 0 owner complaints on file with NHTSA.

How the 2005 compares

Too few model years with complaints to compare.

3recalls

0complaints

0crashes

0fires

0injuries

—median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

3 recalls

Equipment

Oct 26, 2010 · NHTSA campaign 10V525000 · 18,461 vehicles

Problem: Winnebago is recalling certain recreational vehicles equipped with 1200-SERIES norcold refrigerators. The population of refrigerators being addressed contains either a sensing algorithm or thermal switch to shut off power to the refrigerator when high temperatures are detected in order to prevent a potential fire. The response times of the sensor algorithm and thermal switch devices to stop power are not sufficient.

Original NHTSA wording

WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

Risk: The sensing algorithm or thermal switch installed to shut off power to the refrigerator when high temperatures are detected due to a possible hydrogen gas leak May not shut off in sufficient time to prevent a fire.

Original NHTSA wording

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Remedy & notes

Winnebago is working with norcold to identify and notify any affected owners. Owners will be instructed to contact norcold dealers to receive the remedy free of charge. Please see norcold's defect report 10E-049 for additional information. The recall began during December 2010. Owners May contact norcold at 1-800-767-9101 or Winnebago at 1-641-585-3535.

Owners May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to <a href=http://www.safercar.gov>http://www.safercar.gov</a> .

Fuel System

Dec 22, 2004 · NHTSA campaign 04V609000 · 3,538 vehicles

Problem: On certain motor homes built on a 20,700 GVWR or greater Workhorse chassis, there May not be sufficient clearance in the area where the fuel line crosses the frame cross member.

Original NHTSA wording

ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.

Risk: Without clearance, a condition could develop where the cross member May wear into the fuel line and a fuel leak May develop. Fuel leakage, in the presence of an ignition source, could result in a fire.

Original NHTSA wording

WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy & notes

Dealers will repair these motor homes by providing clearance between the fuel line and frame cross member. The fuel line will be inspected and, if necessary, replaced. The recall began January 7, 2005. Owners should contact Winnebago at 1-800-537-1885.

Winnebago recall no. 93. Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-327-4236.

Seat Belts

Dec 18, 2004 · NHTSA campaign 04V608000 · 6,201 vehicles

Problem: Certain seat belt buckles on some motor homes fail to conform to the load requirement of federal motor vehicle safety standard no. 209, "seat belt assemblies."

Original NHTSA wording

CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."

Risk: The seat belt buckle May unlatch in the event of a vehicle crash, possibly resulting in personal injury to the seat occupant.

Original NHTSA wording

THE SEAT BELT BUCKLE MAY UNLATCH IN THE EVENT OF A VEHICLE CRASH, POSSIBLY RESULTING IN PERSONAL INJURY TO THE SEAT OCCUPANT.

Remedy & notes

Dealers will replace the buckles. The recall began on November 12, 2004. Owners should contact amsafe at 1-574-266-8330 or Winnebago at 1-800-537-1885.

Winnebago recall no. 92.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-327-4236.

Recall text as published by NHTSA and the manufacturer.

2005 vs. other Itasca Sunflyer years

Owner complaints by model year; the darker bar is the 2005. Click a bar to switch year.

Questions

Does the 2005 Itasca Sunflyer have recalls?

Yes — NHTSA lists 3 recall campaigns covering the 2005 Itasca Sunflyer, the latest from Oct 26, 2010 (equipment). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2005 Itasca Sunflyer?

Few complaints have been filed with NHTSA for the 2005 Itasca Sunflyer.