2016 International Durastar recalls and problems

The 2016 International Durastar has 7 recalls and 0 owner complaints on file with NHTSA.

Park outside warning. Owners are advised to park outside and away from buildings until the repair is done, because of a fire risk. Campaign: 23V397000.

How the 2016 compares

Too few model years with complaints to compare.

7recalls

0complaints

0crashes

0fires

0injuries

—median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

7 recalls

Service Brakes

Jun 2, 2023 · NHTSA campaign 23V397000 · 6,786 vehicles

Park outside

Problem: Navistar, Inc. (Navistar) is recalling certain 2016 International DuraStar, 2018-2020 and 2023-2024 International 1300FBC Stripped chassis, 2019-2022 IC Bus CE Commercial bus, 2019-2024 IC Bus TC Commercial bus, and 2019-2024 International MV vehicles. The brake pressure switch assembly may leak brake fluid into the brake pressure switch's electrical components and cause an electrical short-circuit.

Risk: An electrical short in the brake pressure switch can overheat the circuit and increase the risk of a fire while driving or parked.

Remedy & notes

Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the brake pressure switch and if necessary, the wire harness or fuse, free of charge. Owner notification letters were mailed September 29, 2023. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23517.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Engine

Dec 23, 2020 · NHTSA campaign 20V810000 · 17,213 vehicles

Problem: Navistar, Inc. (Navistar) is recalling certain 2019-2021 International MV, 2020-2021 International HV, 2014-2020 International DuraStar and 2015-2018 International WorkStar vehicles. When the parking brake is applied and the automatic transmission is still in the drive or reverse position and the stationary PTO switch is engaged by the operator, the engine may rev and overcome the parking brake's ability to keep the vehicle from moving.

Risk: Unexpected Vehicle movement can increase the risk of a crash or injury.

Remedy & notes

Navistar will notify owners, and dealers will update the parameters in the Cummins ECM for feature codes 12VXT or 12VXU that enables the PTO neutral interlock, free of charge. The recall began February 17, 2021. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 20510.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Equipment

Dec 11, 2017 · NHTSA campaign 17V792000 · 10,195 vehicles

Problem: Navistar, Inc. (Navistar) is recalling certain 2000-2001 International 4700, 2000-2002 4900, 2001-2003 8100 (TranStar) and 9100I, 2002-2003, 2005, 2007-2009, 2012-2014 and 2016-2018 DuraStar, 2012 and 2014-2017 ProStar, 2014-2015 TerraStar, and 2018 LT trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' fire extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf

Risk: In the event of a fire, if the fire extinguisher does not function properly, it can increase the risk of injury.

Remedy & notes

Navistar will notify owners, instructing them to notify Kidde for a replacement fire extinguisher, free of charge. The recall is expected to begin February 9, 2018. Owners may contact Navistar customer service at 1-331-332-1590, or contact Kidde customer service toll-free at 1-855-262-3540, or online at www.kidde.com and click on "Product Safety Recall" for more information.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Steering

Sep 20, 2017 · NHTSA campaign 17V575000 · 1,175 vehicles

Problem: Navistar, Inc. (Navistar) is recalling certain 2016 International DuraStar, LoneStar, ProStar, TerraStar, TranStar, WorkStar, 9900i, and IC Bus HC vehicles equipped with certain Spicer D or E series steer axles. The castellated nut on the steer axles may not be properly torqued, allowing the tie rod to loosen.

Risk: If the tie rod loosens, it may disconnect from the steering knuckle, causing a complete loss of steering, increasing the risk of a crash.

Remedy & notes

Navistar will notify owners, and dealers will inspect the torque of the castellated nut and tie rod, tightening it as necessary, free of charge. The recall began on November 8, 2017. Owners may contact Navistar customer service at 1-331-332-1590. Navistar's number for this recall is 17507.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Parking Brake

Mar 8, 2016 · NHTSA campaign 16V141000 · 2,747 vehicles

Problem: Navistar, Inc. (Navistar) is recalling certain model year 2016 International 1300 trucks manufactured February 26, 2015, to May 12, 2015, 2016-2017 International DuraStar trucks manufactured January 28, 2015, to February 4, 2016, International TerraStar trucks manufactured January 28, 2015, to February 1, 2016, and 2016 IC AC transit buses manufactured January 28, 2015, to February 2, 2015. The metal connecting clip that connects the hand operated parking brake actuator cable to the intermediate parking brake cable may fail.

Risk: If the parking brake cable connection fails, the vehicle may unexpectedly roll, increasing the risk of injury or a crash.

Remedy & notes

Navistar will notify owners, and dealers will replace the hand parking brake cable connector clips, free of charge. The recall began on May 3, 2016. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 16504.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Electrical System

Oct 8, 2015 · NHTSA campaign 15V631000 · 74 vehicles

Problem: Navistar Inc. (Navistar) is recalling certain model year 2016 International ProStar trucks manufactured August 5, 2015, to August 14, 2015, DuraStar trucks manufactured August 7, 2015, to August 13, 2015, Paystar trucks manufactured August 11, 2015, to August 14, 2015, and LoneStar trucks manufactured August 10, 2015, to August 14, 2015. In the affected vehicles, the Engine Control Module (ECM) may short circuit, causing the engine to stall without warning.

Risk: An engine that stalls without warning increases the risk of a crash.

Remedy & notes

Navistar will notify owners, and Cummins dealers will replace the ECM, free of charge. The recall began on October 22, 2015. Owners may contact Navistar customer service at 1-800-448-7825, or Cummins customer service at 1-800-343-7357.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Service Brakes

Mar 23, 2015 · NHTSA campaign 15V165000 · 2,222 vehicles

Problem: Navistar, Inc. (Navistar) is recalling certain model year 2015-2016 International 9900, DuraStar, LoneStar, PayStar, ProStar, WorkStar and 2015 International TranStar and IC Bus CE vehicles equipped with a Haldex air braking system. The affected brake actuators may have been manufactured with an incomplete attachment of the internal rubber diaphragm to the actuation mechanism. This could cause dragging or overheated brakes.

Risk: If the brakes drag and overheat there is an increased risk of a wheel end fire.

Remedy & notes

Navistar will notify owners, and dealers will replace the Haldex Life Seal Brake chambers, free of charge. The recall began on June 19, 2015. Owners may contact Navistar customer service at 1-800-448-7825. Navistar's number for this recall is 15504. Note: This recall supersedes recall 14V-806.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall text as published by NHTSA and the manufacturer.

2016 vs. other International Durastar years

Owner complaints by model year; the darker bar is the 2016. Click a bar to switch year.

Questions

Does the 2016 International Durastar have recalls?

Yes — NHTSA lists 7 recall campaigns covering the 2016 International Durastar, the latest from Jun 2, 2023 (service brakes). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2016 International Durastar?

Few complaints have been filed with NHTSA for the 2016 International Durastar.

Is it safe to drive the 2016 International Durastar?

1 recall advises parking outside because of a fire risk. Only vehicles with the recall open are affected — check your VIN at nhtsa.gov/recalls.