2002 International 9200I recalls and problems

The 2002 International 9200I has 4 recalls and 0 owner complaints on file with NHTSA.

How the 2002 compares

Too few model years with complaints to compare.

4recalls

0complaints

0crashes

0fires

0injuries

—median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

4 recalls

Exterior Lighting

May 18, 2023 · NHTSA campaign 23V353000 · 32,880 vehicles

Problem: Navistar, Inc. (Navistar) is recalling certain 2000-2003 International 8100, 2001-2003 International 9100i, 2001-2007 International 9400i, 2001-2010 International 9200i, 2002-2007, 2009 International 8500, 2003-2007, 2013 International 9900i, 2003-2018 International 8600, 2004, 2007 International 9900iX, 2008-2018 International ProStar, 2010-2011, 2013, 2016 International LoneStar, 2011-2012, 2016 International 4400, 2017-2024 International LT, 2018-2024 International RH, 2019-2021 International LS, 2019-2024 International MV vehicles. The back-up lights offer low visibility when the vehicle is in reverse and bobtail mode. Also, the vehicles have not been equipped with additional unobstructed back-up lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

Risk: Low visibility or obstructed back up lights may not alert other drivers that the vehicle is backing up, increasing the risk of a crash.

Remedy & notes

Dealers will replace the existing rear stop/turn signal lights, free of charge. Owner notification letters were mailed May 06, 2024. Owners may contact Navistar's customer service at 1-800-448-7825. Navistar's number for this recall is 23514.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Electrical System

Jun 30, 2004 · NHTSA campaign 04V307000 · 7,610 vehicles

Problem: On certain heavy duty trucks, the engine electrical harness can chafe against sharp edges on the engine.

Original NHTSA wording

ON CERTAIN HEAVY DUTY TRUCKS, THE ENGINE ELECTRICAL HARNESS CAN CHAFE AGAINST SHARP EDGES ON THE ENGINE.

Risk: Sudden acceleration, activation of the engine compression brake, engine speed dropping to idle, alternator overload with possible fire, and a loss of engine ECM power resulting in engine shutdown could occur without warning.

Original NHTSA wording

SUDDEN ACCELERATION, ACTIVATION OF THE ENGINE COMPRESSION BRAKE, ENGINE SPEED DROPPING TO IDLE, ALTERNATOR OVERLOAD WITH POSSIBLE FIRE, AND A LOSS OF ENGINE ECM POWER RESULTING IN ENGINE SHUTDOWN COULD OCCUR WITHOUT WARNING.

Remedy & notes

Dealers will inspect the harness to determine if it is damaged. If damaged, the engine harness will be repaired. All harnesses will be re-routed and stand-off brackets will be added. The recall began on September 8, 2004. Owners can contact International at 1-800-448-7825.

International recall no. 04511. Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Equipment

Feb 27, 2004 · NHTSA campaign 04V100000 · 83,312 vehicles

Problem: On certain conventional trucks equipped with pro-sleeper berths, water intrusion can be found in the bunk control panel area and pool in the tops of the dome light, tv/vcr, and or refrigerator power switches.

Original NHTSA wording

ON CERTAIN CONVENTIONAL TRUCKS EQUIPPED WITH PRO-SLEEPER BERTHS, WATER INTRUSION CAN BE FOUND IN THE BUNK CONTROL PANEL AREA AND POOL IN THE TOPS OF THE DOME LIGHT, TV/VCR, AND OR REFRIGERATOR POWER SWITCHES.

Risk: The circuit boards in the switches could heat up , possibly produce a flame or fire, and cause property damage, personal injury, or death.

Original NHTSA wording

THE CIRCUIT BOARDS IN THE SWITCHES COULD HEAT UP , POSSIBLY PRODUCE A FLAME OR FIRE, AND CAUSE PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.

Remedy & notes

Dealers will install a water shield over the back of the entire bunk control panel. Owner notification began on July 16, 2004. Owners should contact International at 1-800-448-7825.

International recall no. 04503.customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Trailer Hitches

Jun 18, 2003 · NHTSA campaign 03V220000 · 13 vehicles

Problem: On certain heavy duty trucks equipped with jost International jsk 37U series fifth wheels, a fatigue crack can develop in the bracket pin weld under certain loading conditions.

Original NHTSA wording

ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH JOST INTERNATIONAL JSK 37U SERIES FIFTH WHEELS, A FATIGUE CRACK CAN DEVELOP IN THE BRACKET PIN WELD UNDER CERTAIN LOADING CONDITIONS.

Risk: If left undetected or corrected it could lead to the separation of the fifth wheel top plate from its mounting structure, possibly resulting in a crash

Original NHTSA wording

IF LEFT UNDETECTED OR CORRECTED IT COULD LEAD TO THE SEPARATION OF THE FIFTH WHEEL TOP PLATE FROM ITS MOUNTING STRUCTURE, POSSIBLY RESULTING IN A CRASH

Remedy & notes

Dealers will replace the bracket pins and repair instructions free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact jost International at 616-846-7700 or by email to recall@jostinternational.com or International at 1-800-448-7825.

International recall no. 03511.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Recall text as published by NHTSA and the manufacturer.

2002 vs. other International 9200I years

Owner complaints by model year; the darker bar is the 2002. Click a bar to switch year.

Questions

Does the 2002 International 9200I have recalls?

Yes — NHTSA lists 4 recall campaigns covering the 2002 International 9200I, the latest from May 18, 2023 (exterior lighting). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2002 International 9200I?

Few complaints have been filed with NHTSA for the 2002 International 9200I.