2021 Hyundai Santa Fe recalls and problems

The 2021 Hyundai Santa Fe has 7 recalls and 170 owner complaints on file with NHTSA; the most reported problem area is power train.

Park outside warning. Owners are advised to park outside and away from buildings until the repair is done, because of a fire risk. Campaign: 23V181000.

How the 2021 compares

Low

Fewest complaintsMost complaints

Low complaint count among 26 Santa Fe model years — 20th most.

7recalls

170complaints

4crashes

2fires

2injuries

21,000median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

7 recalls

Back Over Prevention

Nov 21, 2024 · NHTSA campaign 24V879000 · 226,118 vehicles

Problem: Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe, Santa Fe HEV, Elantra, Elantra HEV and 2022 Elantra N and Santa Fe PHEV vehicles. Due to a damaged printed circuit board, the rearview camera image may fail to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."

Risk: A rearview image that does not display reduces the driver's visibility and increases the risk of a crash.

Remedy & notes

Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed January 14, 2025. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 271.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153) or go to nhtsa.gov.

Trailer Hitches

Mar 17, 2023 · NHTSA campaign 23V181000 · 584,784 vehicles

Park outside

Problem: Hyundai Motor America (Hyundai) is recalling certain 2019-2023 Santa Fe, 2021-2023 Santa Fe HEV, 2022-2023 Santa Fe Plug-in HEV and Santa Cruz vehicles potentially equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Hyundai dealership. Water accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Risk: A fire while parked or driving can increase the risk of injury.

Remedy & notes

Owners are advised to park their vehicles outside and away from structures until the remedy is completed. Dealers will install a new fuse and wire extension kit as necessary, free of charge. Owner notification letters were mailed starting May 16, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 244. This recall is an expansion of previous recall number 22V-633.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Power Train

Oct 6, 2022 · NHTSA campaign 22V746000 · 56,148 vehicles

Problem: Hyundai Motor Company (Hyundai) is recalling certain 2021-2022 Santa Fe, Sonata, Veloster N, 2022 Santa Cruz, Elantra N, and Kona N vehicles. The vehicle's "fail-safe" limited-mobility drive mode may be impaired, when prompted by a transmission oil pump malfunction, which can result in a complete loss of drive power.

Risk: Loss of drive power increases the risk of a crash.

Remedy & notes

Dealers will inspect and replace the transmission, as necessary. Dealers will also update the transmission control unit software. All repairs will be performed free of charge. Owner notification letters were mailed January 10, 2023. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 236.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Visibility

Dec 28, 2021 · NHTSA campaign 21V00M000 · 26,413 vehicles

Problem: Hyundai Motor America (Hyundai) is recalling certain 2020-2021 Santa Fe, 2021 Sonata, and Elantra vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash.

Risk: A windshield that detaches from a vehicle during a crash can increase the risk of injury.

Remedy & notes

Dealers will remove and reinstall the front windshield panel, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 216.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Fuel System

Jul 9, 2021 · NHTSA campaign 21V524000 · 15,752 vehicles

Problem: Hyundai Motor America (Hyundai) is recalling certain 2021-2022 Santa Fe and Sonata vehicles equipped with 2.5L turbocharged engines. Fuel may leak at the pipe connection between the high-pressure fuel pump and fuel rail.

Risk: A fuel leak increases the risk of a fire.

Remedy & notes

Dealers will inspect and tighten, or replace the fuel pipe as necessary, free of charge. Owner notification letters were mailed on September 3, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 207.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Fuel System

May 3, 2021 · NHTSA campaign 21V308000 · 2 vehicles

Problem: Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles equipped with 2.5-litre Turbo engines. The fuel pipe connecting the high pressure fuel pump to the fuel rail may not have been tightened properly.

Risk: An insufficiently tightened fuel pipe may leak fuel, increasing the risk of a fire.

Remedy & notes

Dealers inspected and tightened the fuel pipe connection, free of charge. The affected vehicles have been repaired and therefore no owner notification letters will be sent. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 206.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Air Bags

Mar 17, 2021 · NHTSA campaign 21V185000 · 10 vehicles

Problem: Hyundai Motor America (Hyundai) is recalling certain 2021 Santa Fe vehicles. The Occupant Detection System (ODS) module may not deactivate the air bag upon detection of a child restraint system in the front passenger seat. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."

Risk: In the event of a crash, deployment of the front passenger air bag, with a child in that seat, can increase the risk of injury to the child.

Remedy & notes

Hyundai will notify owners, and dealers will replace the ODS module, free of charge. All affected vehicles have been remedied as of May 12, 2021. Owners may contact Hyundai customer service at 1-855-371-9460. Hyundai's number for this recall is 202.

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Recall text as published by NHTSA and the manufacturer.

What owners complain about

Power Train51

Unknown or other41

Engine38

Electrical System29

Forward Collision Avoidance18

Visibility14

Fuel System12

Back Over Prevention8

Vehicle Speed Control7

Service Brakes6

Owner complaints filed with NHTSA; one complaint can name several areas. Not verified by NHTSA.

Complaints by year filed

NHTSA investigations

Loss of Motive Power

DP22003 · opened Sep 12, 2022 · closed Dec 12, 2023

Summary

The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitionersâ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODIâs evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan as…

2021 vs. other Hyundai Santa Fe years

Owner complaints by model year; the darker bar is the 2021. Click a bar to switch year.

Questions

Does the 2021 Hyundai Santa Fe have recalls?

Yes — NHTSA lists 7 recall campaigns covering the 2021 Hyundai Santa Fe, the latest from Nov 21, 2024 (back over prevention). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2021 Hyundai Santa Fe?

Owner complaints filed with NHTSA most often mention power train (51), unknown or other (41), engine (38). Complaints are consumer reports and are not verified by NHTSA.

Is it safe to drive the 2021 Hyundai Santa Fe?

1 recall advises parking outside because of a fire risk. Only vehicles with the recall open are affected — check your VIN at nhtsa.gov/recalls.