2003 Honda FSC600 recalls and problems

The 2003 Honda FSC600 has 3 recalls and 1 owner complaint on file with NHTSA; the most reported problem area is equipment.

How the 2003 compares

High

Fewest complaintsMost complaints

High complaint count among 5 FSC600 model years — 2nd most.

3recalls

1complaints

0crashes

0fires

0injuries

500median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

3 recalls

Structure

Jun 25, 2004 · NHTSA campaign 04V290000 · 7,494 vehicles

Problem: On certain motorcycles, the main stand is attached to the frame with two brackets, nuts and bolts. The nuts are spot-welded to the brackets. If clearance exists between the nut and bracket, the spot welds May be broken when the bolt is torqued.

Original NHTSA wording

ON CERTAIN MOTORCYCLES, THE MAIN STAND IS ATTACHED TO THE FRAME WITH TWO BRACKETS, NUTS AND BOLTS. THE NUTS ARE SPOT-WELDED TO THE BRACKETS. IF CLEARANCE EXISTS BETWEEN THE NUT AND BRACKET, THE SPOT WELDS MAY BE BROKEN WHEN THE BOLT IS TORQUED.

Risk: Over time, a bolt can loosen and fall out. The main stand could partially or completely detach from the frame, interfering with or damaging the rear wheel, and increasing the risk of a vehicle crash without warning. A completely detached stand falling on the roadway also creates a hazard for other vehicles.

Original NHTSA wording

OVER TIME, A BOLT CAN LOOSEN AND FALL OUT. THE MAIN STAND COULD PARTIALLY OR COMPLETELY DETACH FROM THE FRAME, INTERFERING WITH OR DAMAGING THE REAR WHEEL, AND INCREASING THE RISK OF A VEHICLE CRASH WITHOUT WARNING. A COMPLETELY DETACHED STAND FALLING ON THE ROADWAY ALSO CREATES A HAZARD FOR OTHER VEHICLES.

Remedy & notes

Dealers will install new brackets, longer bolts and locknuts. Owner notification began on June 29, 2004. Owners should contact american Honda at 1-800-999-1009.

American Honda recall no. P37.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Fuel System

Apr 12, 2004 · NHTSA campaign 04V163000 · 2,497 vehicles

Problem: On certain scooters, some fuel tanks were improperly manufactured and do not meet material strength specifications.

Original NHTSA wording

ON CERTAIN SCOOTERS, SOME FUEL TANKS WERE IMPROPERLY MANUFACTURED AND DO NOT MEET MATERIAL STRENGTH SPECIFICATIONS.

Risk: Engine vibration or riding on bumpy roads could cause these tanks to crack and leak. Fuel leakage, in the presence of an ignition source, can result in a fire.

Original NHTSA wording

ENGINE VIBRATION OR RIDING ON BUMPY ROADS COULD CAUSE THESE TANKS TO CRACK AND LEAK. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, CAN RESULT IN A FIRE.

Remedy & notes

Dealers will perform an inspection procedure that identifies defective fuel tanks. If the fuel tank fails the inspection, the dealer will replace it with an updated fuel tank. Owner notification began during April 16, 2004. Owners should contact Honda at 1-866-784-1870.

Honda recall no. P26.customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Steering

Dec 10, 2003 · NHTSA campaign 03V513000 · 4,997 vehicles

Problem: On certain scooters, excessive clearance between the lower handlebar clamp and handlebar holder creates stress that can eventually cause the handlebar to loosen or detach.

Original NHTSA wording

ON CERTAIN SCOOTERS, EXCESSIVE CLEARANCE BETWEEN THE LOWER HANDLEBAR CLAMP AND HANDLEBAR HOLDER CREATES STRESS THAT CAN EVENTUALLY CAUSE THE HANDLEBAR TO LOOSEN OR DETACH.

Risk: This could result in a loss of steering control, which could lead to a crash.

Original NHTSA wording

THIS COULD RESULT IN A LOSS OF STEERING CONTROL, WHICH COULD LEAD TO A CRASH.

Remedy & notes

Dealers will install two lower handlebar clamps, add washers between the lower clamps and handlebar holder, and install new locknuts. Owner notification began on December 11, 2003. Owners should contact Honda at 1-866-784-1870.

Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Recall text as published by NHTSA and the manufacturer.

What owners complain about

Owner complaints filed with NHTSA; one complaint can name several areas. Not verified by NHTSA.

2003 vs. other Honda FSC600 years

Owner complaints by model year; the darker bar is the 2003. Click a bar to switch year.

Questions

Does the 2003 Honda FSC600 have recalls?

Yes — NHTSA lists 3 recall campaigns covering the 2003 Honda FSC600, the latest from Jun 25, 2004 (structure). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2003 Honda FSC600?

Owner complaints filed with NHTSA most often mention equipment (1), fuel system (1), steering (1). Complaints are consumer reports and are not verified by NHTSA.