2003 Ford Explorer Sport Trac recalls and problems

IN RESPONSE TO AN INFORMATION REQUEST (IR) LETTER SENT BY THE OFFICE OF DEFECTS INVESTIGATION (ODI), FORD STATED CONSUMER REPORTS OF HIGHER THAN EXPECTED EFFORTS WHEN SHIFTING INTO AND OUT OF PARK COULD BE A RESULT OF A GROOVE BEING WORN INTO THE SWING ARM RAMP OF THE STEERING COLUMN. THE SWING ARM IS A COMPONENT BOLTED TO THE STEERING COLUMN THAT ASSISTS IN SHIFTING THROUGH THE TRANSMISSION GEARS.AN ENGINEERING EVALUATION CONDUCTED BY FORD OF RETURNED STEERING COLUMNS FOUND THE GROOVE COULD BE CREATED OVER TIME IF CONSUMER SHIFT MORE QUICKLY FROM THE DRIVE OR REVERSE TO PARK THAN THE BRAKE SHIFT INTERLOCK (BSI) SOLENOID PIN RETRACTS AFTER THE BRAKE PEDAL IS APPLIED. IN NOVEMBER OF 2004, FORD RELEASED A REDESIGNED BSI SOLENOID WITH A SHORTER PIN RETRACTING TIME AS A SERVICEABLE COMPONENT. FORD HAS NOTED THE SHORTER RETRACTION TIME SIGNIFICANTLY LESSENS THE LIKELIHOOD OF BSI SOLENOID PIN TO SWING ARM CONTACT EVEN WITH RAPID CONSUMER SHIFTS.FORD ALSO ISSUED A TECHNICAL SERVICE BULLETIN, TSB 04-22-12, TO INSTRUCT SERVICE TECHNICIANS ON THE PROPER DIAGNOSIS AND VEHICLE REPAIR. REVIEWING COMPLAINTS TO ODI AND DATA SUBMITTED BY FORD, ODI HAS IDENTIFIED 200 ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT AFTER CONSUMERS BELIEVE THEY HAVE SHIFTED THE VEHICLE INTO PARK, RESULTING IN 85 ALLEGED CRASHES AND 32 ALLEGED INJURIES.IN ADDITION TO THE REPORTS OF ALLEGED INCIDENTS OF UNINTENDED VEHICLE MOVEMENT, ODI HAS ALSO IDENTIFIED 883 REPORTS OF CONSUMERS ALLEGING DIFFICULTY OR THE INABI…

ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VER…