2002 Fleetwood Mallard recalls and problems

The 2002 Fleetwood Mallard has 2 recalls and 0 owner complaints on file with NHTSA.

How the 2002 compares

Too few model years with complaints to compare.

2recalls

0complaints

0crashes

0fires

0injuries

—median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

2 recalls

Equipment

Mar 19, 2007 · NHTSA campaign 07V120000 · 167,096 vehicles

Problem: Certain motor homes and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, May have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Original NHTSA wording

CERTAIN MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Risk: Release of coolant under certain conditions could ignite and result in a fire.

Original NHTSA wording

RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.

Remedy & notes

Fleetwood will be working with dometic in order to repair these refrigerators (please see 06E076). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle INC. To manage this campaign. Stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners May contact dometic/stericycle at 1-888-446-5157 or Fleetwood at 1-800-322-8216.

Customers May contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.

Equipment

Nov 4, 2003 · NHTSA campaign 03V452000 · 60,877 vehicles

Problem: On certain travel trailers equipped with samsung microwave ovens, these ovens were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This May cause the oven to activate without pressing any key pads.

Original NHTSA wording

ON CERTAIN TRAVEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE OVENS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.

Risk: An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.

Original NHTSA wording

AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.

Remedy & notes

Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800-932-3837 or Fleetwood at 1-800-629-8454.

Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Recall text as published by NHTSA and the manufacturer.

NHTSA investigations

INADVERTENT SLIDE-OUT EXTENSION MOVEMENT

PE06005 · opened Jan 20, 2006 · closed May 2, 2006

Summary

THIS INVESTIGATION WAS OPENED BASED ON ODI'S RECEIPT OF A CONGRESSIONAL LETTER ON BEHALF OF A CONSTITUENT.THE CONSTITUENT REPORTED INCIDENTS WHERE THE SLIDE OUT ROOM OF HIS MOTOR HOME WOULD INADVERTENTLY MOVE (EXTEND) DURING HIGHWAY USE.ODI WAS CONCERNED THAT A FULLY EXTENDED SLIDE OUT WOULD DEGRADE THE VEHICLE'S DYNAMIC HANDLING CHARACTERISTICS AND/OR POSSIBLY IMPACT AN OBJECT OR ANOTHER VEHICLE, RESULTING IN A CRASH.ODI CONTACTED FLEETWOOD AND DISCOVERED THAT SLIDE OUT ROOMS WERE INSTALLED IN MOTOR HOMES, TRAVEL TRAILERS AND FOLDING TRAILERS. AS PART OF THE INVESTIGATION ODI VISITED A RV SHOW AND THE FLEETWOOD PAXINOS PLANT TO EXAMINE SLIDE OUTS IN VARIOUS NEW MAKE AND MODEL VEHICLES AND GAIN AN UNDERSTANDING OF HOW THE SYSTEMS WORK.DURING THE INVESTIGATION ODI LEARNED THAT THERE ARE TWO METHODS USED TO EXTEND SLIDE OUT ROOMS.SOME MANUFACTURERS USE HYDRAULIC SYSTEMS AND OTHERS, SUCH AS FLEETWOOD, USE AN ELECTRIC MOTOR. (CONTINUED ON PAGE 2)

2002 vs. other Fleetwood Mallard years

Owner complaints by model year; the darker bar is the 2002. Click a bar to switch year.

Questions

Does the 2002 Fleetwood Mallard have recalls?

Yes — NHTSA lists 2 recall campaigns covering the 2002 Fleetwood Mallard, the latest from Mar 19, 2007 (equipment). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2002 Fleetwood Mallard?

Few complaints have been filed with NHTSA for the 2002 Fleetwood Mallard.