2004 Coachmen Freelander recalls and problems

The 2004 Coachmen Freelander has 4 recalls and 1 owner complaint on file with NHTSA; the most reported problem area is equipment.

How the 2004 compares

Average

Fewest complaintsMost complaints

Average complaint count among 10 Freelander model years — 5th most.

4recalls

1complaints

0crashes

0fires

0injuries

4,200median miles

Owner complaints filed with NHTSA, not verified and not adjusted for sales. Ranking compares this model's own years only.

Does your car have an open recall?
Recalls apply to specific vehicles. Only a VIN lookup on NHTSA's official site shows whether yours is affected and still unrepaired.

Check your VIN →

4 recalls

Equipment

Dec 4, 2008 · NHTSA campaign 08V639000 · 13,662 vehicles

Problem: Coachmen is recalling 13,662 my 2002-2008 motor homes, fifth wheel and travel trailers equipped with glass shower doors and manufactured from June 15, 2001 thorugh August 6, 2007. When pressure is applied to the towel bar on the glass shower door, the edge of the bar May contact the glass.

Original NHTSA wording

COACHMEN IS RECALLING 13,662 MY 2002-2008 MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH GLASS SHOWER DOORS AND MANUFACTURED FROM JUNE 15, 2001 THORUGH AUGUST 6, 2007. WHEN PRESSURE IS APPLIED TO THE TOWEL BAR ON THE GLASS SHOWER DOOR, THE EDGE OF THE BAR MAY CONTACT THE GLASS.

Risk: Glass breakage May occur which could cause personal injury.

Original NHTSA wording

GLASS BREAKAGE MAY OCCUR WHICH COULD CAUSE PERSONAL INJURY.

Remedy & notes

Owners will be provided with new mounting hardware for the towel bar and installation instructions. If an owner is not comfortable replacing the hardware themselves, a dealer will install the hardware at no cost to them. The recall is expected to begin on or about December 19, 2008. Owners May contact Coachmen at 1-574-825-5821.

Customers May contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to www.safercar.gov.

Equipment

Jun 25, 2008 · NHTSA campaign 08V279000 · 37,293 vehicles

Problem: Coachmen is recalling 37,293 motorhomes and fifth wheel travel trailers equipped with a two-door refrigerator manufactured by the dometic corporation. The refrigerator May have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.

Original NHTSA wording

COACHMEN IS RECALLING 37,293 MOTORHOMES AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Risk: Extended operation of a leaking cooling unit could lead to a fire from gas which might escape.

Original NHTSA wording

EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.

Remedy & notes

Coachmen is working with dometic in order to repair these refrigerators (please see 08E032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle INC. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners May contact dometic/stericycle at 1-888-446-5157 or Coachmen at 574-825-5821.

Customers May also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.

Engine

Oct 28, 2004 · NHTSA campaign 04V515000 · 88 vehicles

Problem: On motor homes built on Ford e-series chassis, the air filter element material process resulted in an air filter paper element that can smolder or burn. This change in filter paper composition combined with the configuration of the air induction system, May allow hot carbon particles to contact the air filter element during certain driving conditions that create hot particles.

Original NHTSA wording

ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.

Risk: These hot particles May ignite the air filter element with the potential for air induction system damage or underhood fire.

Original NHTSA wording

THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.

Remedy & notes

Ford is conducting the owner notification and remedy for this campaign. Dealers will inspect and replace the air filter element. Owners should contact Ford at 1-800-392-3673 or Coachmen at 219-825-5821.

Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Equipment

Mar 8, 2004 · NHTSA campaign 04V119000 · 122 vehicles

Problem: On certain class c MINI-motorhomes, the wiring harness routed between the back of the refrigerator and the refrigerator cabinet could come in direct contact with the refrigerator burner tube and cooling unit.

Original NHTSA wording

ON CERTAIN CLASS C MINI-MOTORHOMES, THE WIRING HARNESS ROUTED BETWEEN THE BACK OF THE REFRIGERATOR AND THE REFRIGERATOR CABINET COULD COME IN DIRECT CONTACT WITH THE REFRIGERATOR BURNER TUBE AND COOLING UNIT.

Risk: If contact occurs, the wire insulation material May melt, due to the operating temperature of the burner tube and cooling unit which could lead to a fire.

Original NHTSA wording

IF CONTACT OCCURS, THE WIRE INSULATION MATERIAL MAY MELT, DUE TO THE OPERATING TEMPERATURE OF THE BURNER TUBE AND COOLING UNIT WHICH COULD LEAD TO A FIRE.

Remedy & notes

Dealers will relocate the wire harness. The recall begaon on March 29, 2004. Owners should contact Winnebago at 1-800-453-6064.

Also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-DASH-2-DOT (1-888-327-4236).

Recall text as published by NHTSA and the manufacturer.

What owners complain about

Equipment1

Owner complaints filed with NHTSA; one complaint can name several areas. Not verified by NHTSA.

2004 vs. other Coachmen Freelander years

Owner complaints by model year; the darker bar is the 2004. Click a bar to switch year.

Questions

Does the 2004 Coachmen Freelander have recalls?

Yes — NHTSA lists 4 recall campaigns covering the 2004 Coachmen Freelander, the latest from Dec 4, 2008 (equipment). A recall applies to specific vehicles: enter your VIN at nhtsa.gov/recalls to see whether yours is affected and still open.

What are the most common problems with the 2004 Coachmen Freelander?

Owner complaints filed with NHTSA most often mention equipment (1). Complaints are consumer reports and are not verified by NHTSA.