2006 Cadillac CTS recalls and problems

On December 17, 2010, General Motors (GM) notified the NHTSA that it had decided certain 2005 - 2007 model year Cadillac CTS vehicles contain a safety related defect.GM stated that certain CTS vehicles contain a passenger sensing system mat, manufactured by IEE, in the front passenger seat that may flex causing the mat to kink, bend or fold.If this flexing causes the connections in the mat to break, the passenger airbag could become disabled.Non-deployment of the front passenger air bag in the event of a crash necessitating that air bag's deployment may reduce protection of the passenger and increase the risk or severity of injury to them.This issue was assigned recall number 10V-644.On February 8, 2011, RMD mailed an information request (IR) letter to IEE requesting a list of purchasers for any company that was sold the same or similar defective mats.RMD also requested IEE supply the year, make and models of compatible vehicles for each of the mats it listed in its response.IEE responded on February 15, 2011, reporting that the mats recalled in GM recall 10V-644 were developed specifically for the 2005-2007 Cadillac CTS.IEE noted that, ...the CTS Sensor Mat is not the same or similar to any other sensor mat manufactured by IEE.IEE further explained that the sensor mats were sold to Lear Corp. (Lear), for incorporation into seat assemblies, with the seat assemblies finally being sold to GM.Also, some sensor mats were sold to Integrated Manufacturing and Assembly, LLC (IMA) wh…

IN JULY OF 2007 THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED PE07-037 TO INVESTIGATE ALLEGATIONS THAT THE REAR DIFFERENTIAL MAY FAIL CAUSING A LOSS OF MOTIVE POWER, AND IN SOME INSTANCES A LOSS OF CONTROL, IN MODEL YEAR (MY) 2004 THROUGH 2006 CADILLAC CTS, CTS-V, AND STS VEHICLES.AS A RESULT OF THAT INVESTIGATION GM ISSUED RECALL 07V-589 TO CORRECT A LEAKING PINION SEAL PROBLEM.EA07-017 WAS OPENED TO INVESTIGATE COMPLAINTS OF FRACTURED REAR DIFFERENTIAL HOUSINGS OR REAR HALF SHAFTS IN HIGH PERFORMANCE CADILLAC CTS-V VEHICLES.ACCORDING TO GM, THESE FAILURES RESULTED FROM THE CUMULATIVE DAMAGE FROM MULTIPLE POWER HOP EVENTS THAT CAN OCCUR DURING VERY AGGRESSIVE DRIVING. IN FEBRUARY 2008 INVESTIGATORS FROM ODI MET WITH GM REPRESENTATIVES TO CONDUCT TESTING OF THE SUBJECT CTS-V VEHICLES.DURING THE TESTING THE SUBJECT VEHICLES WERE SUBJECTED TO CONSIDERABLE TORSIONAL FORCES FROM STANDING STARTS AND WHILE DRIVING.POWER HOP OCCURRED DURING SOME OF THE MOST AGGRESSIVE DRIVING MANEUVERS.THE TESTING DID NOT RESULT IN FAILURE OF ANY REAR DRIVETRAIN COMPONENTS.THE ENGINEERING DESIGN AND TESTING DATA SUPPLIED TO ODI BY GM AND THE RESULTS OF THE TESTING CONDUCTED BY ODI TEND TO SUPPORT GM'S POSITION THAT THE DIFFERENTIAL DESIGN IS NOT DEFECTIVE. COMPLAINTS LISTED IN THE FAILURE REPORT DO NOT INCLUDE THOSE INDICATIVE OF FAILURE OF THE REAR PINION SEAL IN CTS-V VEHICLES COVERED BY RECALL 07V-589. FURTHER INVESTIGATION IN THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCE…

ODI EVALUATED TWO DIFFERENT ALLEGED DEFECTS INVOLVING REAR DRIVETRAIN COMPONENTS DURING THIS PRELIMINARY EVALUATION.GM IS CONDUCTING A RECALL TO ADDRESS ONE OF THE DEFECT CONDITIONS AND ODI HAS OPENED AN ENGINEERING ANALYSIS TO CONTINUE ITS INVESTIGATION OF THE OTHER ALLEGED DEFECT. ON DECEMBER 19, 2007, GM SUBMITTED A DEFECT INFORMATION REPORT TO NHTSA CONCERNING DEFECTIVE REAR AXLE PINION SEALS IN APPROXIMATELY 275,936 MODEL YEAR (MY) 2005-07 CADILLAC CTS, STS AND SRX VEHICLES AS WELL AS MY 2006-07 PONTIAC SOLSTICE AND MY 2007 SATURN SKY VEHICLES (RECALL 07V-589).ON STS AND SRX VEHICLES WITH ALL WHEEL DRIVE, THE FRONT AXLE PINION SEAL ALSO DOES NOT MEET ALL OF GM'S SPECIFICATIONS AND MAY EXPERIENCE A FLUID LEAK.GM INDICATED THAT THE SEAL SUPPLIER MADE AN UNAUTHORIZED CHANGE TO THE PINION SEAL MATERIAL.LEAKING PINION SEALS COULD RESULT IN LOSS OF REAR DIFFERENTIAL LUBRICATION WHICH COULD RESULT IN REAR WHEEL LOCK-UP AND LOSS OF VEHICLE CONTROL. ON DECEMBER 7, 2007, ODI OPENED AN ENGINEERING ANALYSIS (EA07-017) TO INVESTIGATE COMPLAINTS OF REAR DRIVETRAIN COMPONENT FAILURE (E.G., FRACTURED REAR DIFFERENTIAL CARRIER HOUSING OR REAR AXLE HALF SHAFTS) WHILE DRIVING IN APPROXIMATELY 7,600 MY 2004 THROUGH 2006 CADILLAC CTS-V VEHICLES.THIS CONDITION MAY RESULT IN A LOSS OF MOTIVE POWER AND VEHICLE DISABLEMENT AND IS NOT ADDRESSED BY RECALL 07V-589.ODI IDENTIFIED 35 COMPLAINTS (16 TO ODI AND 19 TO GM) AND 128 WARRANTY CLAIMS POTENTIALLY RELATED TO THIS CONDITION (SEE EA07-017 OPENIN…